Air Suspension Compressor Wont Turn Off

The only way to turn it off was to turn it off at the panel.

Air suspension compressor wont turn off.

Last night the pump came on and would not turn off. Total cost about a 2500. Add or adjust jounce bumper for full contact before air bag bottoms out especially for 4wd vehicles. The lincoln town car comes with an air suspension system known as air ride if you are experiencing problems with the air suspension system consider resetting it by turning it off then back on.

This may cure an intermittent problem. Motor wont turn off keeps trying too run when full of air. If the compressor is failing to come on at all then that is a sign that it has either failed or it is having an issue. It should start and at cut out pressure you should see and hear the contacts in the switch trip.

It could either not engage the air suspension compressor at all or even worse keep it engaged for longer that required. The suspension system cannot function without it. Most suspension systems are self regulated and will automatically turn the compressor on and off according to the system s requirements. 1 cause of air bag mutilation is insufficient pressure for load or use.

That pressure cut out level may be in the 100 psi through to 175 psi level depending on the brand and size of your air compressor. It is the compressor pressure switch that is supposed to shut the air compressor off when the tank pressure reaches the cut out pressure level. If it does not you may have further problems with the system that require the assistance of a dealer. I have a firestone ride rite system on a truck i just purchased used.

Air bag is suspension limiter in compression. If the air suspension compressor is kept engaged for too long it can get damaged. Please power off the compressor dump the air to below cut in pull the top off the switch double check the wiring make sure that the switch is rated for 240 volts and power up the compressor. Tasmania australia recently the suspension air compressor completely burnt out and i had the vw dealership replace it and the relay and 40 amp fuse.

Consider adding a on board air compressor system for convenient air pressure adjustment. Air bag bottomed out. Faulty relay or blown fuse the air suspension compressor relay is known to fail. The controller showed pressures exceeding 100 psi and the only way i could turn it off was to disconnect the wiring even after turnin off the ignition.